J. Michael Moore and David Jones
Storage
Insects
Control of Insects in Stored Tobacco
All Fumigants Are Very Hazardous and Must Be Handled Carefully
Good management is required on the part of growers to maintain the quality and value of tobacco which is stored from one season to another. In general, tobacco should be stored in a clean, dry, insect free facility, such as a packhouse or bulk curing barn. The costs of production, harvesting, and curing of carryover tobacco have already been invested and the carryover tobacco is additional profit for the producer if quality is maintained by proper storage. Care should be taken to insure that the tobacco is sufficiently dry when placed in storage. Storage facilities should be maintained insect free and the tobacco should be checked periodically to insure proper storage and the absence of insect or moisture damage. If damaged tobacco is located, steps should be taken to minimize the amount of tobacco damaged.
If space is available tobacco may be left in the curing racks or boxes for storage. Following the curing process the curing barn is probably the most sanitary facility on the farm having eliminated the threat of insects existing in the barn. However, once the barn is opened and tobacco moved in or out new insect contamination may occur. The same may happen over time with the natural movement of insects. Tobacco stored in sheets should be dry throughout the sheet when placed in storage.
Care should be taken to provide good ventilation under and around the tobacco. Stack sheets on wooden pallets or rails, especially if the storage area floor is concrete or near ground level. A vapor barrier of polyethylene or roofing paper placed on the floor will reduce the infiltration of moisture. Leave space to move around the stacks when making periodic checks every 2-4 weeks. If bulk curing barns are used the fans may be run occasionally to insure the tobacco remains dry.
Tobacco may be redried at temperatures not to exceed 100o F to avoid color changes and reductions in quality. Heat treatment of loosely packed DRY tobacco at 140 degrees F for one hour may be used to reduce the number of insects initially. No residual effect of this treatment should be expected. Tobacco may be reinfested by insects at a later date and may require re-treatment.
Tobacco moths and the cigarette beetle, commonly attack tobacco stored on the farm. Of these the tobacco moth is most serious. The larvae, which cause all of the damage, are pinkish to yellow to off-white caterpillars about 1/2 inch long. They burrow into and form ragged holes in the cured leaves. Entire leaves may be consumed except for the midrib and large veins. The larvae also deposit webbing and fecal pellets on the infested tobacco. The adult tobacco moth is a small gray moth about 3/8 inch long with a 5/8 inch wingspread.
Cigarette beetle adults are light to dark-brown, hump-backed insects about 1/8 inch long. Adults leave tiny holes as they emerge from pupae cases within the tobacco. The hairy C-shaped larvae, which cause most of the damage, are whitish with a brown head and are about 1/5 inch long. They leave behind powdery waste which can give tobacco an unpleasant flavor.
Control of established infestations is difficult, so prevention is very important. The most important step in prevention is sanitation. Before tobacco is placed in storage, a clean storage area should be prepared. Clean out and burn all tobacco and debris from the storage area. Plant trash in the storage area might harbor insects which can move to the tobacco.
Tobacco Moths: The tobacco and the storage area should also be treated with Bacillus thuringiensis to help prevent tobacco moth infestation. Apply a fine spray to loose tobacco AS IT IS BEING SHEETED. It is very hard to repack sheets and get the good coverage required. One suggestion might be apply B.t. as a fine mist as the tobacco is sent through a conditioning cylinder (a tumbler). Rates for treatment with B.t. are as follows:
Tobacco: Dipel 2X - 2.5 tsp per qt water/100 lbs of tobacco
Storage area only: Dipel 2X - 6 tsp per 2.5 gal water, use 0.5 gal/1000 sq ft surface.
Stored tobacco should be checked every two to four weeks during the fall and winter for signs of insects and new damage. If tobacco moths are found, tobacco should be treated with B.t. as described above. Treating the outside of piles and/or the sheets will probably not control an established infestation. Piles must be taken apart and the tobacco treated as loose leaves before resheeting. Sheets may also be treated.
Cigarette Beetles: Malathion is labeled for treatment of storage facilities as a residual spray for the control of cigarette beetles. There are no labeled cigarette beetle preventive insecticides for direct application to tobacco. Treat the storage area only as follows:
Storage area only: Malathion 5 lb/gal EC - 1 pt per 2.5 gallons of water
Clean the area thoroughly; spray walls, floors, and ceilings to the point of run-off, preferably at least two weeks before storing tobacco.
If cigarette beetles are found in stored tobacco, tobacco may be fumigated. A number of materials (methyl bromide, aluminum phosphide [Phostoxin], and magnesium phosphide) are labeled and may be used for this purpose. Of these materials, Phostoxin is probably the preferred product for this use because of its pelleted or tablet formulation.
Current regulations make it very difficult for farmers to legally carry out fumigation on their own. Therefore, fumigation should probably be done by a professional.
Remember that fumigation controls only insects which are present; it is not a preventive treatment. Most fumigants can cause damage to metals, especially copper wiring in motors, when in contact at high concentrations. DO NOT treat stored tobacco with pesticides not specifically labeled for this purpose. Always READ and FOLLOW label instructions.
The use of heat in the curing barn to kill infesting insects is the safest and simplest method to eliminate insects in cured tobacco. To simplify this process tobacco which will be stored through the winter should be left in the curing barn in the curing racks or boxes. Regular inspection of the tobacco and occasional use of the barn fan and/or furnace will maintain low moisture content and reduce the potential for insect infestation. For further information contact your local county extension office.
Trade names are used only for information. The Cooperative Extension Service, the University of Georgia College of Agricultural & Environmental Sciences, does not guarantee or warrant published standards on any product mentioned; neither does the use of a trade or brand name imply approval of any product to the exclusion of others that may also be suitable.
The University of Georgia and Ft. Valley State College, the U.S. Department of Agriculture and counties of the state cooperating. The Cooperative Extension Service offers educational programs, assistance and materials to all people without regard to race, color, national origin, age, sex or disability.
An Equal Opportunity Employer/Affirmative Action Organization Committed to a Diverse Work Force
Issued in furtherance of Cooperative Extension work, Acts of May 18 and June 30, 1914, The University of Georgia College of Agricultural and Environmental Sciences and the U.S. Department of Agriculture cooperating.
Gale A. Buchanan, Dean and Director